欢迎来到嘉祥同信环卫设备有限公司

当前位置:主页 > 新闻动态 > 行业新闻 >

三轮吸粪车真空泵的保养秘诀交给你?

文章出处:http://www.txhw88.com/ 发表时间:2019-04-24
1、检查真空泵管路及别离处有无松动现象。用手转动真空泵,试看真空泵能否灵活。
1. Check the loosening of vacuum pump pipeline and other places. Turn the vacuum pump by hand to see if it is flexible.
2、向轴承体内参与轴承润滑机油,观察油位应在油标的中心线处,润滑油应及时改换或补充。
2. Participate in bearing lubricating oil to bearing body. Observe oil level should be at the center line of oil mark. Lubricating oil should be changed or supplemented in time.
3、拧下真空泵泵体的引水螺塞,灌注引水(或引浆)。
3. Turn down the diversion bolt of the vacuum pump body and pour the diversion water (or slurry).
4、关好出水管路的闸阀和出口压力表及进口真空表。
4. Close gate valves and outlet pressure gauges and import vacuum gauges.
5、点动电机,试看电机转向能否正确。
5. Point the motor to see if the motor steering is correct.
6、东风吸粪车开动电机,当真空泵正常运转后,翻开出口压力表和进口真空泵,视其显现出恰当压力后,逐渐翻开闸阀,同时检查电机负荷情况。
6. Dongfeng dung suction truck starts the motor. When the vacuum pump is in normal operation, the outlet pressure gauge and the imported vacuum pump are turned on. After the appropriate pressure is shown, the gate valve is gradually turned on and the load of the motor is checked.
7、尽量控制真空泵的流量和扬程在标牌上注明的范围内,以保证真空泵在最高效率点运转,才干获得最大的节能效果。
7. Controlling the flow rate and head of the vacuum pump as far as possible within the range indicated on the sign, so as to ensure the operation of the vacuum pump at the most efficient point and achieve the greatest energy-saving effect.
8、三轮吸粪车的真空泵在运转过程中,轴承温度不能超越环境温度35C,最高温度不得超越80C 。
8. During the operation of the vacuum pump of the three-wheel dung suction truck, the bearing temperature can not exceed the ambient temperature of 35C, and the maximum temperature can not exceed 80C.
9、如发现真空泵有异常声音应立即停车检查缘由。
二手吸粪车
9. If abnormal sound of vacuum pump is found, stop immediately to check the reason.
10、三轮吸粪车的真空泵要中止运用时,先关闭闸阀、压力表,然后中止电机。
10. When the vacuum pump of the three-wheeled dung suction truck is to stop operation, first close the gate valve and pressure gauge, and then stop the motor.
11、三轮吸粪车的真空泵在工作第一个月内,经100小时改换润滑油,以后每个500小时,换油一次。
11. During the first month of operation, the vacuum pump of the three-wheeled dung suction truck changed the lubricant for 100 hours, and then changed the oil once every 500 hours.
12、经常调整填料压盖,保证填料室内的滴漏情况正常(以成滴漏出为宜)。
12. Regularly adjust the packing cap to ensure that the drip leakage in the packing room is normal (drip leakage is appropriate).
13、定期检查轴套的磨损情况,磨损较大后应及时改换。
13. Periodically check the wear condition of the sleeve, and replace it in time after the wear is serious.
14、真空泵在寒冬时节运用时,停车后,需将泵体下部放水螺塞拧开将介质放净。防止冻裂。
14. When the vacuum pump is in operation in cold winter, after stopping, it is necessary to unscrew the screw plug at the lower part of the pump body to remove the medium. Prevent frost cracking.
15、真空泵长期停用,需将泵全部拆开,擦干水分,将转动部位及别离处涂以油脂装好,妥善保管。
15. When the vacuum pump is out of service for a long time, it is necessary to dismantle all the pumps, dry the water, and coat the rotating parts and other places with grease for proper storage.
本文由二手吸粪车进行编写,想要了解更多的产品及更详细的精彩内容,请关注我们的官方网站:http://www.txhw88.com
This article is written by the second-hand dung suction truck. For more products and more details, please pay attention to our official website: http://www.txhw88.com.

返回顶部