全国服务热线
18254766999(微信同号)
联系我们 CONTACT US
联系我们


嘉祥同信环卫设备有限公司

联系人:黄经理

电话:18254766999

网站:http://www.txhw88.com

地址:山东省济宁市嘉祥县

常见问题您现在的位置:首页>新闻动态>常见问题>二手吸粪车空气滤清器需要好好保养吗?

二手吸粪车空气滤清器需要好好保养吗?

来源:http://www.txhw88.com 日期:2020-03-17 发布人:同信环卫小编 浏览量:

[导读]:  二手吸粪车是由成千上万的零部件筑巢,空气过滤器是不起眼的部分之一,尽管他并不直接影响感染性汽车的技术性能,但实践中,他有一个很大的
  二手吸粪车是由成千上万的零部件筑巢,空气过滤器是不起眼的部分之一,尽管他并不直接影响感染性汽车的技术性能,但实践中,他有一个很大的影响在使用机器的生活。一方面,如果没有空气滤清器的过滤效果,发动机会吸入大量的灰尘、空气微粒,导致气缸严重磨损;另一方面,如果在使用的过程中,不剩下维持很长一段时间,空气过滤器的滤芯将粘满灰尘的空气,这不仅让过滤器可以下降,而且还会阻碍空气的流通,导致混合物太厚,使机器工作异常。因此,做好汽车的空气滤清器是至关重要的。
  The second-hand manure truck is built by thousands of parts, and the air filter is one of the unimportant parts. Although it does not directly affect the technical performance of the infectious car, in practice, it has a great impact on the life of using the machine. On the one hand, if there is no filtering effect of the air filter, the engine will inhale a lot of dust and air particles, which will cause serious wear of the cylinder; on the other hand, if there is not a long time left in the use process, the filter element of the air filter will be filled with dust air, which will not only make the filter drop, but also hinder the air flow, resulting in too thick mixture, Make the machine work abnormally. Therefore, it is very important to do a good job in the air filter of the car.
二手吸粪车
  如果间接吸收渣土车的活塞组和气缸加速磨损,会形成严重的“拉缸”现象,这在干燥多沙的工作环境中尤为严重。空气过滤器安装在化油器或进气管的前面,起到过滤空气中的灰尘和沙粒的作用,保证进入气缸的空气充足、清洁。
  If the piston group and cylinder of the indirect absorption muck truck accelerate wear, it will form a serious "pull cylinder" phenomenon, which is especially serious in the dry and sandy working environment. The air filter is installed in front of the carburetor or intake pipe to filter the dust and sand in the air and ensure that the air entering the cylinder is sufficient and clean.
  湿式滤芯由海绵形状的聚氨酯材料制成。安装时应加些油,用手搓擦,以吸收空气中的异物。如果滤芯结垢后,可使用清洁油来停止清洗,消防污垢也应更换新的滤芯。
  The wet filter element is made of polyurethane material in the shape of sponge. When installing, add some oil and rub with hands to absorb foreign matters in the air. If the filter element is dirty, clean oil can be used to stop cleaning, and the fire-fighting dirt should also be replaced with a new filter element.
  吸粪车在启动机运转时,进气是间歇性的,这样会引起空气滤清器壳体内的空气振动,如果空气压力抖动过大,有时会影响启动机的进气。此外,此时还会增加进气噪声。为了抑制进气噪声,可以增大空气滤清器壳体的体积。
  When the suction truck is running, the air intake is intermittent, which will cause air vibration in the air filter housing. If the air pressure jitters too much, sometimes it will affect the air intake of the starter. In addition, the intake noise will be increased at this time. In order to suppress the intake noise, the volume of the air cleaner housing can be increased.
  二手吸粪车的空气过滤器一般有纸和油浴式两种。纸过滤因其过滤效率高、质量轻、成本低、维护方便等优点而得到广泛的应用。在正常条件下,纸滤芯的过滤效率高达99.5%,油浴滤芯的过滤效率为95-96%。汽车上常用的空气过滤器是纸过滤器,分为干式和湿式两种。对于干燥的滤芯,一旦浸入油或水,过滤阻力会急剧增大,所以清洗时一定不要接触水或油,否则需要更换新的部件。
  The air filter of the second-hand sucking car generally has two kinds of paper and oil bath. Paper filtration is widely used because of its high efficiency, light weight, low cost and convenient maintenance. Under normal conditions, the filter efficiency of paper filter element is as high as 99.5%, and that of oil bath filter element is 95-96%. The commonly used air filter in automobile is paper filter, which is divided into dry type and wet type. For the dry filter element, once it is immersed in oil or water, the filtration resistance will increase sharply, so do not contact with water or oil during cleaning, otherwise new parts need to be replaced.
  吸粪车空气滤清器的滤芯分为干式滤芯和湿式滤芯。干燥的过滤材料是滤纸或无纺布。为了增加空气通过的面积,大部分滤芯处理有很多细小的褶皱。当滤芯受到轻微污染时,可用压缩空气吹净,当滤芯受到严重污染时应及时更换新芯。
  The filter element of the air filter of the suction truck is divided into dry filter element and wet filter element. The dry filter material is filter paper or non-woven fabric. In order to increase the air passing area, most of the filter elements have many small wrinkles. When the filter element is slightly polluted, the compressed air can be used to blow it out. When the filter element is seriously polluted, the new core shall be replaced in time.
  用于吸粪车湿式滤芯采用海绵状聚氨酯材料制造,安装时应滴一些油,用手均匀揉捏,以吸收空气中的异物。如果滤芯结垢后,可使用清洁油来停止清洗,消防污垢也应更换新的滤芯。
  The wet filter element for the manure truck is made of sponge polyurethane material. During installation, some oil should be dropped and kneaded evenly by hand to absorb foreign matters in the air. If the filter element is dirty, clean oil can be used to stop cleaning, and the fire-fighting dirt should also be replaced with a new filter element.
  以上是二手吸粪车厂家为大家介绍的相关内容,想要了解更多内容,欢迎访问网站:http://www.txhw88.comThe above is the relevant content introduced by the second-hand manure truck manufacturer. For more information, please visit the website: http://www.txhw88.com